How to Fix a Car That Stalls

Опубликовал Admin
15-06-2017, 06:40
2 863
0
There are many things that could cause a car to stall. Fortunately, this usually does not signal a major repair to your vehicle, and it can generally be fixed through some relatively minor adjustments or repairs.

Steps

  1. Consider the complexity of your car before beginning and take your car to a trusted repair shop. Modern cars (mid-nineties or later) have an ignition and fuel system that are in large part computer controlled, and it will be difficult for you to make any adjustments. You will want to take it into the shop to address this problem.
  2. Check for check engine lights or maintenance required lights on the dash board instrument cluster. Any fuel or ignition problem in modern CPU controlled engine systems will likely cause a code to be displayed, a check engine light, or maintenance required light to come on. If you are not able to use a scan tool, or don't have access to one, many auto parts retailer offer the use of one free of charge.
  3. The stall is likely caused by either a problem in the electrical system or in the fuel system. Your engine stops running because it is not igniting fuel in the cylinders. This occurs either because there is not any gas to ignite, or because it lacks the electrical charge to ignite it.
    • Note that older, carburetor type fuel systems may have too much fuel entering the cylinders, a condition known as flooding.
  4. Drive the car up and down steep hills. Does this change the performance of the engine, or cause it to stall? This might indicate a clogged fuel filter. Replacing the fuel filter can often be relatively cheap and easy once you find out where it is located.
    • Note that some vehicles have fuel filters located in the gas tank, and can be very difficult to access.
    • Diesel fuel filters and multi-fuel filters can cost over $100.00, U.S.
  5. Does the car idle roughly and stall when at idle? If your car has a distributor, you may need to adjust the timing. With the right tools and know how, this is an easy and free task. If your vehicle has fuel injection, you can check the injector by using a screwdriver or mechanics scope. The injectors will make a clicking/snapping sound if working. No sound may indicate a bad injector. It could also indicate an electrical failure with the circuit that drives the fuel injector. Also, check the Ignition Control Module, which controls the timing of the voltage going to spark plugs, and supplies the spark to ignite the fuel/air mixture.
  6. If your car has a distributor, you might consider changing the cap, rotor, wires and plugs. This is effectively a tune-up. This can usually be done even by a relative novice to car repair, and take a couple of hours with the right tools. It seems counterintuitive, but even the wires and distributor decay over time, and transmit less electricity. This tune-up may solve your stalling problem — even if it does not, your car should run better and get better mileage afterwards.
  7. If your car diesels when you turn off the ignition, it means that your car most likely has a carburetor and the idle speed adjustment is too high. Dieseling describes the situation where you turn off the key, yet the car continues to run for a few seconds or longer, eventually sputtering to a stop. This does not occur on fuel-injected vehicles because when the ignition is turned off so is the fuel supply to the engine as well as the spark plugs.
  8. In rare cases, your car may stall due to what is commonly called a "vapor lock," a situation that occurs when the fuel lines supplying gas to the engine become hot enough to boil the gas in the line turning it into vapor. Fuel pumps are designed to pump liquid not “vapor” and thus fail to provide enough fuel pressure. However, a clogged fuel tank vent system can cause a vacuum in the fuel line that causes fuel to eventually stop reaching the engine. This also is a problem unique to carbureted engines. Fuel injected engines commonly have "closed loop" fuel delivery systems that make this condition unlikely to occur. Try opening your gas cap. If you hear a "whooshing" sound, like when you open a can of coffee, it means the gas tank is not venting properly. Now try starting the car. It should work after a couple tries. This is usually found only in older cars. If you have it, this will probably happen again, so your tank vent system should be checked for blockage. More often than not, the problem can be traced to a cheap replacement locking gas cap. A cheap fix is to drill a small hole in your gas cap to allow air in and prevent the vacuum from forming, but the gas cap should not be left this way.

Tips

  • If you can find a friend who knows how to work on cars, ask them to teach you how to do these things.
  • Certain modern cars may stall on hot days due to the fuel pump. The fuel pump is located at the back of the gas tank, and is cooled by the gasoline itself. On hot days where the car has been running for a while, the fuel pump may overheat and stop working, stalling the car. To prevent this issue, always keep the gas tank at least 3/8 full, or else you might find yourself calling a friend to bring you a gas can!
  • Tune-up: most people do not know that a tune-up has changed entirely since the days of points and condensers. Now, besides spark plugs and fuel filters, Oxygen sensors should be replaced at 100k miles. This alone will improve fuel economy more than anything besides tire inflation. They will cause stalling as well if they are not functioning correctly. Another very important thing to check is to see if the Mass Air Flow sensor is dirty. This will cause poor performance and possible stalling. They can be cleaned with mass air flow sensor cleaner which is essentially quick dry electronic cleaner.
  • Many newer vehicles with fuel injection have an idle air control valve. These can/will become dirty and sticky over time and cause idling and stalling issues. Most can be removed and cleaned with a throttle body cleaner. A carbon fouled throttle body can cause poor idling and stalling as well.

Warnings

  • Working on your car can be dangerous. Don't attempt any of these fixes while the car is running.
Теги:
Information
Users of Guests are not allowed to comment this publication.